Product ID:LAP SEALANT
MSDS Date:07/06/1989
FSC:5610
NIIN:00N024571
MSDS Number: BPCKS

MANVILLE SALES CORP

DENVER, CO 80217
US

Emergency Phone: 303-978-4900

Info Phone: 303-978-4900

Cage: 75165

SCHULLER INTERNATIONAL INC.

5108 DENVER, CO 80217-5108 US

Telephone: 303-978-4900

Cage: 75165

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 39%

OSHA PEL 100 PPM;150 PPM STEL

ACGIH TLV: 100 PPM;150 PPM STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

ELASTOMER (EPDM)

Fraction By Weight: 61%

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:VAP IS A CNS DEPRESSANT: EXCESSIVE
EXPOS CAN CAUSE IRRIT OF THE RESP TRACT & EYES. RPTD/PRLNGD SKIN
CONT MAY RESULT IN DERM. CHRONIC: REPEATED/PROLONGED SKIN CONT
CAUSES DEFATTING/DERMATITIS.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:INHAL: MAY CAUSE IRRITATION OF THE RESPIRATORY
TRACT, HEADACHE, NAUSEA AND VOMITING. SKIN CONTACT: PRIMARY SKIN
IRRITANT. SKIN ABSORPTION: SKIN IRRITATION. INGEST: LOCAL
IRRITATION WITH BURNING SENSAT ION IN MOUTH AND ESOPHAGUS, NAUSEA.
EYES: BURNING SENSATION, TEARING.
Medical Cond Aggravated by Exposure:CHRONIC RESPIRATORY AND SKIN
DISEASES.

First Aid:INHAL: REMOVE TO FRESH AIR. SKIN: WASH AFFECTED AREAS WITH
SOAP AND WATER. INGEST: UNLESS QUANTITY IS EXCESSIVE VOMITING OR
LAVAGE IS NOT RECOMMENDED. CONSULT MD. EYE: FLUSH WITH LARGE
QUANTITIES OF W ATER FOR AT LEAST 15 MINUTES. IF IRRITATION
PERSISTS CONSULT MD.

Flash Point Method:CC
Flash Point:81.0F,27.2C
Lower Limits:1%
Upper Limits:6%
Extinguishing Media:CO, DRY CHEMICAL. ALCOHOLIC FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:STORE AND USE SWAY FROM SOURCES OF HEAT.

Spill Release Procedures:REMOVE SOURCES OF HEAT AND IGNITION. USE
ABSORBENT (SAND, EARTH, SAWDUST, ETC.) TO CLEAN UP SMALL SPILLS AND
RESIDUES. DISCARD IN A SEALED LABELED CONTAINER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE IN CLOSED CONTAINERS IN A COOL,
WELL-VENTILATED AREA AWAY FROM SOURCES OF HEAT, FLAME, IGNITION AND
STRONG OXIDIZING AGENTS.
Other Precautions:USE ONLY WITH ADEQUATE NATURAL OR MECHANICAL
VENTILATION.

Respiratory Protection:USE A NIOSH/MSHA APPROVED RESPIRATOR SUCH AS MSA
MODEL 448975 (GMA CANISTER 448974) OR EQUIVALENT FOR PROTECTION
AGAINST PETROLEUM SOLVENT FUMES WHEN ABOVE PEL OF 100 PPM.
Ventilation:LOCAL VENTILATION RECOMMENDED TO KEEP TLV BELOW 100 PPM.
Protective Gloves:IMPERMEABLE GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:SKIN CREAMS OR EMOLLIENTS ARE USEFUL FOR
PROTECTION AGAINST SKIN IRRITATION.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

Boiling Pt:B.P. Text:291F,144C
Vapor Pres:8 @ 25C
Vapor Density:3.66
Spec Gravity:1.12
Evaporation Rate & Reference:9.2 (ETHER=1)
Solubility in Water:INSOLUBLE
Appearance and Odor:BLACK OR WHITE VISCOUS PASTE WITH STRONG
HYDROCARBON ODOR.
Percent Volatiles by Volume:50.8

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:SOURCES OF IGNITION, HEAT AND FLAME.
Hazardous Decomposition Products:CO*2, CO, HYDROCARBONS AND FUMES.

Waste Disposal Methods:SEAL AND LABEL WASTE CONTAINER. SEND TO APPROVED
CHEMICAL WASTE LANDFILL I/A/W FEDERAL, STATE AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.